In thousands of homes on well water, acidic water causes thinning of copper pipes, pinhole leaks, and numerous copper pipe leaks over time. Acidic water can also cause pinhole leaks and pipe failure over time.0 to 7.Signs of acid water are corrosion of fixtures, blue staining (from copper pipes) or rust staining (from iron pipes). Acidic waters can be of good quality and are typically low in buffering calcium minerals, but are high in dissolved carbon-dioxide gas, which can cause the low pH or acidity.
Calcite Neutralizer Filters An acidic water filtration system is also known as a calcite neutralizer filter. A neutral pH is 7. Most backwashing acid neutralizer filters are set to backwash once a week for eight to ten minutes. The most common type of acid neutralizer filter has an automatic backwash control valve. If the pressure tank, check valve and pressure switch are installed with copper piping the copper piping should be replaced with PVC or stainless steel pipes up to the inlet of neutralizer filter.
The frequency and length of the backwash cycle can be easily adjusted on the control valve. Acidic water filtration systems can easily correct and neutralize a low pH in well water.This type of neutralizer also acts as a filter removing sediment and small amounts of rust from the water, and then backwashing it out once every week or so.5 the water can be made alkaline which will then reduce or eliminate pipe corrosion.The size of the system is directly proportional to the flow rate of the water, in gallons or liters per minute. The higher the flow rate, and the more gallons per minute flows through the pipes, the larger the system required. For higher flow demands and in homes with 3 to 4 bathrooms and larger families, a 2.
It is OK to have copper pipes installed on the outlet of neutralizer filter since the water is tilting disc check valve neutralized at this point and the pipe will be protected. These minerals dissolve into the water, making it less corrosive. This eliminates the effects of corrosive water chemistries and can help to prevent corrosion of piping and fixtures. Common causes for acidic water are acid rainfall due to atmospheric carbon dioxide and other airborne pollutants, runoff from mining spoils, and decomposition of plant materials.5 cubic foot filter is recommended.
